Jul 05, 2020

Detroit Series 60 Engine Fault Codes

detroit series 60 engine fault codes

Detroit Diesel Series 60 Engines only; Codes 43, 44,45,51 and 53 are critical codes and if they are shown; the Stop Engine Light will come on which causes the engine protections to engage and your engine may shut down. All other codes will cause the Check Engine Light to come on which will not engage the engine protections and will allow the engine to continue running;

What’s the Code? | Trip Sheet Central

Section 60.2 Troubleshooting Flash Code 61, SID 1/2/3/4/5/6/FMI 0. This diagnostic condition is typically:‪ Bad injector harness and or connection (high resistance) Poor vehicle grounds Sticky solenoid valve Note: The injector diagnostic SID indicates which cylinder number has an injector with a long response time. The injector number describes the cylinder and or bank which has the injector with a long response time.

Series 60 DDEC V Troubleshooting - Detroit Diesel Engine ...

The Nexiq Pro-Link with a Detroit Diesel card is the fastest way to troublshoot the Series 60 for engine faults. Series 60 service manuals can be obtained from most authorized Detroit Diesel dealers. The Series 60 troubleshooting guide contains a list of codes and their meanings.

[DOC] Detroit Engine Codes

Title: File Size: Download Link: DDC-SVC-BRO-0115 fault codes.pdf: 623.6kb: Download: Detroit Diesel 60 Fault Codes.pdf: 3.6Mb: Download: Detroit Diesel DDEC 5 Fault ...

Detroit Diesel Series 60 Common Failures and Problems ...

In this video, I show you a Detroit EGR Delete Failure, the Detroit Diesel 60 Series had an EGR delete done by another shop and later driver had issues of low power then rapid coolant loss. He ...

PID/SID FLASH SPN FMI PID/SID ID CODE FAULT DESCRIPTION

Detroit Diesel Engine Troubleshooting. Detroit Repair Manuals. Skip to content. Menu. Home; Contact Us; ... Section 57 Flash Code 55 - J1939 Data Link Fault. Figure 1. ECM/ECU. 57.1 Description of Flash Code 55. 57.2 Troubleshooting Flash Code 55, SID 231/216/FMI 12/14. Series 60 DDEC V Troubleshooting Guide - 6SE570: Generated on 10-13-2008 ...

DETROIT DIESEL SERIES 60 DDEC VI TROUBLESHOOTING MANUAL ...

SERIES 60 EGR TECHNICIAN'S MANUAL DDEC V CODES To read DDEC V codes, use the Detroit Diesel Diagnostic Link (DDDL). The DDDL will display active and inactive fault codes which are listed in Table 9-1.

DETROIT DIESEL Fault Codes DTC - Trucks, Tractor ...

Page 45 Detroit Diesel DDEC IV On-Highway (A 629 540 50 00) On-board diagnostics, 15.10.2003 There are two types of diagnostic codes: - An active code- a fault present at the time when checking for codes

Freightliner Fault Codes list (MID, PID, SID, FMI ...

The Detroit Diesel Series 60 is an inline-six 4 stroke diesel engine produced since 1987. At that time, it differed from most on-highway engines by using an overhead camshaft and "drive by wire" electronic control.In 1993, it was popular on many USA buses in the 11.1 L (677 cu in) displacement.

Kindle File Format Fault Codes For Detroit Diesel Series ...

CODES FAULT DESCRIPTION 98 18 PID 98 2115 Oil Level Low 98 1 PID 98 2115 Oil Level Very Low ... 247 9 PID 247 2615 MCM Engine Hours Data not received or stopped arriving ... 630 14 SID 155 2615 MCM Fault Code Table Inconsistant - Upgrade MCM Software 639 14 SID 231 2153 J1939 Data Link Failure 701 3 SID 26 2211 Digital Output 4 09 Circuit ...

detroit 60 series engine trouble | NastyZ28.com

60 series engine codes.....shuts down Created On Tuesday April 19, 2011 17:10 moparmania ... forgot to say it is a 94 FREIGHTLINER WITH A 95 DETROIT 12.7 60 SERIES DDECIII 430/470 HP ENGINE. ... there are too many codes randomly dispalayed to be a mechanical fault ,I'll bet it is a wiring issue,myself Go to the ECM remove the wiring harness on ...

Detroit Diesel Fault Codes | TruckManuals.com

I have 2 codes eng rsrvc 128s332 14 and eng rsrvc 128s155 14 on a Detroit 60 freightliner century 2008. Show More. ... Engine code fault one detroit 60series 515 engine just had the regen filter clean ... I got a code 128 076 14 SID on a freightliner Cascadia 2008 Engine Detroit Series 60 14 Liter 515HP can you tell me what it is and the cause? ...

9 DDEC V Codes - Daimler

Fault indication: DCU: Engine warning in DCU display. CIU: Flash code. Flash code. Electrical fault: 2.5 Value fault: None. Symptom: The engine start time will increase, uses only crankshaft sensor. Conditions for fault code: Incorrect timing. Possible reason: • Polarity fault. The cables to the cam speed sensor is shifted. • Intermittent ...

Detroit 60 DDEC 6 Electronic Diagnostic Manual ...

There is no boost pressure when code 46 is active as the engine won't rev up. I tried disconnecting all sensors one at a time and noticed that when fuel temp sensor was disconnected, code 23 came on, code 46 went off, engine could now accelerate, and Diagnostic link was properly displaying all pressure and temp readings.

Front Page - Detroit Diesel ECM

Check for fault codes as listed on the diagnostic chart of the DDDL7.0 Detroit Diesel software, and repair or remove active and inactive codes first before proceeding to troubleshoot the injectors. Perform dual and triple cylinder cut-off tests by turning off the cylinders using the Detroit Diesel DDDL7.0 software.

DETROIT DIESEL SERIES 60 ENGINE - Fitzgerald Glider Kits

If you have the Detroit motor, you can read the fault codes off the dash. Call them in to any Freightliner dealer or Detroit Diesel mechanic, and they can tell you what those codes are.

TROUBLESHOOTING FLASH CODE 61 - tpub.com

1999 Detroit 60 series engine, DDEC1V ECM This morning I cleared the codes, turned the truck on and let it throttle and after about 10 minutes the engine warning and engine stop light came on. The fan chipped in and power was lost. When i check teh prolink tool it shows an active codes PID:110...

Series 60 Engine Support | Demand Detroit

[a] If codes 146/152 or 147/153 are logged, refer to section 10.16 for Series 50 engines. For Series 60 engines, refer to section 10.18. Or, call Detroit Diesel Technical

ATTENTION - Grand Diesel

A Detroit Diesel fault code indicates a specific problem with a Detroit Diesel Series 60 engine. The fault code is displayed when the "check engine" light is activated on a truck powered by the aforementioned engine. The Detroit Diesel Series 60 is an inline-6 four-cycle diesel engine that was first produced in 1987.

DiagnosticLink: Home

I got the following fault codes on a 2005 series 60 detroit. Can you tell me what they are and if they are related? 128-147 2 SID 128-059 3 SID 128-146 7 SID … read more

How do you clear Detroit fault codes in a freightliner ...

Covers: Detroit Series 60 DDEC V Troubleshooting & Diagnostics Pages: 751 File size: 33mb Format: PDF files (zipped) Compatibility: Windows/Mac computers Notes: Bookmarked, searchable, printable, instant download This troubleshooting manual describes procedures to diagnose the Detroit Series 60 engine with DDEC V (5) electronic controls. In this manual you will find detailed step-by-step ...

Detroit diesel series 60 14-liter engine codes - Fixya

Faulty ecm. These will usually cause engine shutdown immediatly. Then the fault code shutdown usually has a fault code light on the dash SEL light [red] then about 7 seconds laer engine shutdown. A yellow cel on the dashboard will NOT shutdown the engine- that is just a warning light alerting you to a sensor fault or a sensor problem.

Diesel Laptops Detroit Diesel Diagnostic Link Laptop ...

[b] If code 100/3 and any other codes except 100/4 were logged, refer to section 36.3.3. 6. If active codes 100/3 or 4 were not logged, warm up engine until either codes are logged or the engine temperature (COOLANT TEMP or OIL TEMP or DDR) has been greater than 60 C (140 F) for one minute.

Flash Code readings on a Detroit Diesel 60 series eng

Some DETROIT DIESEL Engines Service Manuals PDF are above the page - 2-cycle, 4-cycle, 50, 53, DDC EPA07 60, 71, 92, 149. The motor company Detroit Diesel is one of the best all over the world and for many years has been maintaining its leadership in the American market in the class of motor for trucks. This is achieved thanks to the engines of the famous S60 series, which have proven to be ...


Detroit Series 60 Engine Fault Codes



The most popular ebook you must read is Detroit Series 60 Engine Fault Codes. I am sure you will love the Detroit Series 60 Engine Fault Codes. You can download it to your laptop through easy steps.

Detroit Series 60 Engine Fault Codes